Your nearest location
EAST KNOXVILLE
865-546-1414
contact us
Home New Diesel Generator Sets D80 GC Generator Set

D80 GC Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Generator Set Specifications

Maximum Rating 80 ekW
Minimum Rating 80 ekW
Emissions/Fuel Strategy U.S. EPA Cert., Tier 3
Voltage 208 to 600 Volts
Frequency 60 Hz
Speed 1800 rpm
Duty Cycle Standby

Engine Specifications

Engine Model C4.4, In-line 4, 4-cycle diesel
Bore 4.1in
Stroke 5in
Displacement 269in³
Compression Ratio 16.7:1
Aspiration Turbocharged
Fuel System Common Rail
Governor Type Mechanical, ADEM™A4

Generator Set Dimensions

Length - Maximum 82.6in
Width - Maximum 43.3in
Height - Maximum 52.9in
Dry Weight - Genset (maximum) 950lb

Standard Equipment

  • Air Inlet System
    • Air cleaner; light duty with disposable element
    • Air cleaner
  • Cooling System
    • Radiator and cooling fan with guards
    • Fan drive, battery charging alternator drive
    • Caterpillar extended life coolant
    • Coolant drain line with valve
  • Control Panel
    • GCCP 1.2 Control panel
  • Exhaust System
    • Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
  • Fuel System
    • Standard open set fuel tank/base supplied base, formed steel with single wall integral 24-hour fuel tank
  • Generator
    • Circuit breaker, IEC, 3 pole, mounted in tower panel
    • Voltage regulator (single phase sensing)
    • IP23 Protection
    • Segregated low voltage (AC/DC) wiring panel
    • 12 Leads
    • Tower panel, IP22, bottom cable entry
  • Governing System
    • Mechanical and electrical governing system - model dependent
  • Lube System
    • Lubricating oil
    • Oil drain line with valve
  • Mounting System
    • Includes lifting provision and drag points
    • Termination points for coolant and lube oil drain lines
    • Captive linear vibration isolators between base and engine-generator
  • Starting/charging System
    • Batteries
    • 24V battery with rack and cables
  • General
    • Engine and alternator pre-paint, Caterpillar yellow

Optional Equipment

  • Alternator System
    • 3 Phase sensing
    • Anti-condensation heater
    • R Frame auxilliary winding
    • Permanent magnet excitation (PMG)
  • Circuit Breakers
    • Circuit breaker upgrades - 4 Pole circuit reaker to 250A, 400A and 630 A
  • Cooling System
    • Low coolant level shutdown
    • Coolant heater
    • Low coolant temperature alarm
  • Control Panel Options
    • Earth fault (2 wire only)
    • Overload shutdown via breaker
    • Earth leakage (2 wire only)
    • Volt free contacts
    • Panel mounted audible alarm
    • Battery charger
    • GCCP 1.2 Control panel
    • Control panel heater
    • Voltage adjust potentiometer
    • Emergency stop with key
    • Speed adjust potentiometer
  • Enclosures
    • Sound attenuated Level 2 enclosure
  • Fuel System
    • High fuel level alarm
    • Open set narrow tankbase
    • Low fuel level alarm
    • Bunded fuel tank
    • Low fuel level shutdown
    • Compact skidbase for open set
    • Skidbase for CALG enclosure sets
  • Global Certifications
    • Certification for CIS
  • Mounting Options
    • Battery removal
    • Industrial silencer
    • Electronic governor
    • External single point lift - enclosure
    • Silencer installation kit
  • Special Packing/inspectons For Shipment
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
  • General - Accessories / Miscellaneous
    • Stone guards/rad trans flange
    • Packing case - canopied set
    • Packing case - compact set