+
Your nearest location
EAST KNOXVILLE
865-546-1414
contact us
Home New Diesel Generator Sets D175 GC Generator Set

D175 GC Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Generator Set Specifications

Maximum Rating 175 ekW
Minimum Rating 175 ekW
Emissions/Fuel Strategy U.S. EPA Cert., Tier 3
Voltage 208 to 600 Volts
Frequency 60 Hz
Speed 1800 rpm
Duty Cycle Standby

Engine Specifications

Engine Model C7.1 I-6, 4-Cycle Diesel
Bore 4.1in
Stroke 5.31in
Displacement 427.8in³
Compression Ratio 16.7:1
Aspiration Turbocharged, Air to Air Aftercooled
Fuel System Electronic, Common Rail
Governor Type ADEM™A4

Generator Set Dimensions

Length - Maximum 103.7in
Width - Maximum 51.2in
Height - Maximum 58.7in
Dry Weight - Genset (maximum) 3741lb

Standard Equipment

  • Air Inlet System
    • Air cleaner; light duty with disposable element
  • Control Panels
    • GCCP 1.2 Control panel
  • Cooling System
    • Coolant drain line with valves
    • Fan drive, battery charging alternator drive
    • Caterpillar extended life coolant
    • Radiator and cooling fan with guards
  • Generator And Generator Attachments
    • Tower panel, IP22, bottom cable entry
    • IP23 Protection
    • 12 Leads
    • Circuit breaker, IEC, 3 pole, mounted in tower panel
    • Segregated low voltage (AC/DC) wiring panel
    • Voltage regulator (single phase sensing)
  • Exhaust System
    • Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
  • Fuel System
    • Base, formed steel with single wall integral 24-hour fuel tank
    • Standard open set fuel tank/base supplied
  • Lube System
    • Lubricating oil
    • Oil drain line with valve
  • Mounting System
    • Termination points for coolant and lube oil drain lines
    • Includes lifting provision and drag points
    • Captive linear vibration isolators between base and engine-generator
  • Starting / Charging System
    • 24V battery with rack and cables
  • Governing System
    • Mechanical and electrical governing system - model dependent
  • General
    • Engine and alternator pre-paint, Caterpillar yellow

Optional Equipment

  • Alternator System
    • Permanent magnet excitation (PMG)
    • Quatrature droop king
    • Alternator removal
    • 3 Phase sensing
    • R Frame auxiliary winding: R2273L4 SE aux alt 07, aux alt 08 and aux alt 10
    • Anti-condensation heater
    • Optional LC Frame alternator with coastal insulation protection
  • Circuit Breakers
    • Padlockable breaker device
    • 4 Pole 250A, 400A and 630A Circuit breakers
  • Control Panel Options
    • Earth fault (2 wire only)
    • Speed adjust contacts
    • Panel mounted audible alarm
    • Volt free contacts
    • Earth leakage (2 wire only)
    • Overload shutdown via breaker
    • Control panel heater
    • Speed adjust potentiometer
    • Battery charger
    • Emergency stop with key
  • Control System
    • Static battery charger
    • Volt free contacts for common alarm
    • Volt free contacts for generator set running
    • GCCP 1.2
  • Cooling System
    • Low coolant temperature
    • Coolant heater
    • Low coolant level shutdown
  • Enclosures
    • Sound attenuated level 2 enclosure
  • Mounting Options
    • Electronic governor
    • Silencer installation kit
    • Industrial silencer removal
    • Battery removal
    • Residential silencer
  • Fuel Systems
    • Low fuel level alarm
    • Compact skidbase for open sets
    • DEFRA bunded fuel tank
    • Open set narrow tankbase
    • Low fuel level shutdown
    • Skidbase for CALG enclosure sets
    • High fuel level alarm
  • Test Reports
    • PGS Test report @ 1.0 power factor
    • PGS Test report @ 0.8 power factor
  • General
    • Stone guards/radiator trans flange
  • Global Certifications
    • Certification for CIS
  • Power Termination
    • Circuit breaker, IEC, 4 pole
  • Accessories / Miscellaneous
    • Packing case - compact set
    • Packing case - canopied set