Your nearest location
EAST KNOXVILLE
865-546-1414
contact us
Home New Diesel Generator Sets C4.4 Generator Set

C4.4 Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Generator Set Specifications

Maximum Rating 100 ekW
Minimum Rating 72 ekW
Emissions/Fuel Strategy U.S. EPA Cert., Tier 3
Voltage 110 to 480 Volts
Frequency 60 Hz
Speed 1800 rpm
Duty Cycle Standby, Prime

Engine Specifications

Engine Model Cat® C4.4
Bore 4.1in
Stroke 5in
Displacement 268.5in³
Compression Ratio 16.2:1, 17.25:1, 18.2:1 or 18.3:1
Aspiration Turbocharged
Fuel System Direct Injection or Common Rail
Governor Type Mechanical

Generator Set Dimensions

Length - Maximum 75.8in
Width - Maximum 44.1in
Height - Maximum 53.6in

Standard Equipment

  • Air Inlet System
    • Air cleaner; light duty with disposable element
  • Cooling System
    • Radiator and cooling fan with guards
    • Coolant drain line with valve
    • Fan drive, battery charging alternator drive
    • Caterpillar extended life coolant
  • Control Panel
    • GCCP 1.3
  • Exhaust System
    • Stub pipe, gaskets, raincap and SAE exhaust flange for customer use - shipped loose
  • Fuel System
    • Standard open set fuel tank/base supplied base, formed steel with single wall integral 8-hour fuel tank
  • Generator
    • Voltage regulator (single phase sensing)
    • 12 Leads
    • IP23 Protection
    • Circuit breaker, IEC, 3 pole, mounted in tower panel
    • Segregated low voltage (AC/DC) wiring panel
    • Tower panel, IP22, bottom cable entry
  • Governing System
    • Mechanical and electrical governing system - model dependent
  • Lube System
    • Oil drain line with valve
    • Lubricating oil
  • Mounting System
    • Termination points for coolant and lube oil drain lines
    • Includes lifting provision and drag points
    • Captive linear vibration isolators between base and engine-generator
  • Starting/charging System
    • 24V battery with rack and cables
    • Batteries
  • General
    • Engine and alternator pre-paint, Caterpillar yellow

Optional Equipment

  • Alternator System
    • Permanent magnet excitation (PMG)
    • R Frame auxilliary winding
    • Anti-condensation heater
    • R Frame auxilliary winding
    • Quadrature droop kit
    • LC Frame alternator with coastal insulation protection
    • 3 phase sensing
  • Circuit Breakers
    • Circuit breaker upgrades - 4 Pole circuit reaker to 250A, 400A and 630 A
  • Cooling System
    • Low coolant level shutdown
    • Coolant heater
    • Low coolant temperature alarm
  • Control Panel Options
    • GCCP 1.3
    • Control panel heater
    • Earth leakage (2 wire only)
    • Panel mounted audible alarm
    • Volt free contacts
    • Emergency stop with key
    • Battery charger
    • Overload shutdown via breaker
    • Speed adjust potentiometer
    • Voltage adjust potentiometer
  • Enclosures
    • Sound attenuated Level 2 enclosure
    • Sound attenuated Level 1 (galv)
    • Rental pack - CAE rental option only
  • European Certifications
    • Upgrade to STD set for CE
  • Fuel System
    • Skidbase for CALG enclosure sets
    • Low fuel level alarm
    • Open set narrow tankbase
    • Low fuel level shutdown
    • Compact skidbase for open set
    • High fuel level alarm
    • Bunded fuel tank
  • Global Certifications
    • Certification for CIS
  • Mounting Options
    • Electronic governor
    • Industrial silencer
    • External single point lift - enclosure
    • Battery removal
    • Silencer installation kit
  • Special Packing/inspectons For Shipment
    • PGS Test report @ 0.8 power factor
    • PGS Test report @ 1.0 power factor
  • General - Accessories / Miscellaneous
    • Packing case - compact set
    • Packing case - canopied set
    • Stone guards/rad trans flange