C175-20

Standard Equipment

• Air Inlet System

  4 x Single element air cleaner canisters with service indicator(s).

• Control Panel

  24 Volt DC operation 4 Programmable relay Inputs 4 Programmable relay output Alarm acknowledge Amps (per phase & average) Auto/start/stop control Coolant temperature DC volts Digital indicators Cat ECS 100 Emergency stop Emergency stop pushbutton Engine cool-down timer Engine cycle crank Environmental sealed front face Failure to start (overcrank) Frequency (Hz) High Coolant temperature Lamp test Low coolant level Low oil pressure Oil pressure (psi, kPa or bar) Operating hours Overspeed RPM Speed adjust Text alarm/event descriptions. True RMS AC metering, 3-phase, +/-2% accuracy Volts (L-L & L-N) Wall mounted controls: Warning/shutdown Indicators:

• Cooling System

  AC Inlet: 6" ANSI / AC Outlet: 3-1/2" ANSI Coolant sensors JW Inlet: 6" ANSI / JW Outlet: 5" Cat Flange SCAC cooling

• Exhaust System

  Dry exhaust manifold Dual ANSI 18" / DIN 450 flanges. Shipped loose. Support required from installation

• Fuel System

  10 Micron spin on yype 4 Micron spin on type Engine mounted filters x 3 Filters x 3 Primary fuel filter water/fuel water separator Secondary/tertiary fuel filters

• Generators And Attachments

  3 Phase brushless 3 Phase voltage sensing 6 Leads Anti-condensation space heater Class H temperature rise at 40C ambient Exciter diode monitor Form wound IEC platinum stator RTDs Min / max exciter limiter NEMA Class H insulation Permanent magnet excitation (PMG) Reactive droop capability RFI suppression Right side extension box, bottom cable entry Salient pole Voltage regulator

• Governing System

  ADEM A4 Redundant shutdown (Overspeed protection through a duplicate speed sensing system)

• Lube System

  Fumes disposal Gear type lube oil pump Integral lube Oil cooler Lubricating oil Oil drain lines and valve Oil filter, filler and dipstick

• Mounting Systems

  Rails - Engine/generator Rubber anti-vibration mounts - shipped loose

• Starting / Charging System

  Batteries and battery rack w/cables Battery disconnect switch Dual 24 volt electric starting motors

• General

  Paint - Caterpillar yellow with high gloss black rails Right hand servicing SAE standard rotation

Optional Equipment

• Air Inlet Systems

  Single element air cleaner

• Control Panel

  EMCP 4.4 Controller and MV and HV power connection locations Controller voltage and current sensing groups E-Stop Generator harness Generator temperature monitoring Interconnect harness Load share module Modbus monitoring of packages Speed adjust Vandal proof panel door Annunciator modules Customer interface options

• Cooling System

  Fuel cooler Package mounted radiators Remote radiators

• Crankcase Systems

  Crankcase ventilation system Explosive relief valves

• Exhaust System

  Exhaust collectors/manifold Front housing - Prime or continuous Front housing - Standby or mission critical Mufflers (15, 25 and 34 dBA silencers)

• Fuel System

  Primary fuel filter

• Generator

  Anti-condensation heater Internal excitation (IE) Oversize and premium generators Permanent magnet excitation (PMG)

• Generators And Attachments

  Differential current transformers Generator air cleaner Medium voltage - 3000 Frames - 60 Hz, 3 phase, 1800 rpm, FW, PM, No of leads=6, Pitch 0.6667 Thermostat for space heater

• Instrumentation

  Pyrometer and thermocouples

• Lube System

  Drain group oil pans Electric prelube pumps Lube oil heater Lubricating oil Oil filters

• Mounting System

  IBC vibration isolators - Shipped loose Rubber anti-vibration mounts Spring type linear vibration isolators

• Power Termination

  Circuit breakers, IEC compliant Circuit breakers, UL listed

• Special Tests / Reports

  Custom generator TVA report Generator test report Genset fuel consumption test PGS Test report @ 0.8 power factor PGS Test report @ 1.0 power factor Special test charge - Engine only Standard engine test charge Standard genset TVA (Torsional Vibration Analysis) report

• Starting / Charging System

  20 Amp Battery chargers 24 Volt battery set - Dry 24 Volt electric starting motor 35 Amp Battery chargers 50 Amp Battery chargers Air pressure regulator Air starting motor Charging alternators - Dry Jacket water heaters Starter location covers

• General

  Barring groups: Control GP - air powered bar group Engine air powered Engine barring group Manual Special paint - 3500