3516E Low Voltage Generator Set

Standard Equipment

• Air Inlet System

  Single element canister type with service indicator Air cleaner

• Cooling

  Package mounted radiator

• Exhaust

  Exhaust flange outlet

• Fuel	Primary fuel filter with integral water separator Fuel priming pump

• Generator

  IP23 Protection Matched to the performance and output characteristics of Cat engines

• Power Termination

  Busbar

• Starting/charging

  Heavy duty starting system Charging alternator

• Control Panel

  Communications: 6 Programmable digital inputs Programmable protective relaying functions: Low oil pressure Environmental sealed front face Volts (L-L & L-N) Emergency stop pushbutton Serial annunciator module data link Reverse power (kW) (32) Engine cycle crank Lamp test Over/under frequency (81 o/u) kW-hr (total) Speed adjust True RMS AC metering, 3-phase, +/-2% accuracy Engine cool-down timer Overcurrent (50/51) Reverse reactive power (kVAr) (32RV) kW (per phase, average & percent) kVAr-hr (total) Generator phase sequence Oil pressure (psi, kPa or bar) Low coolant temperature Amps (per phase & average) Generator mounted - rear facing Over/under voltage (27/59) Low coolant level Accessory module data link kVAr (per phase, average & percent) Cat ECS controller includes: Failure to start (overcrank) 2 Programmable relay outputs (Form C) Cat ECS 100 Overspeed 2 Programmable digital outputs DC volts Frequency (Hz) High coolant temperature Warning/shutdown with common LED indication of shutdowns for: Operating hours 4 Programmable relay outputs (Form A) Coolant temperature Power factor (per phase & average) Digital indication for: Panel lights Text alarm/event descriptions Controls: 24 Volt DC operation Alarm acknowledge Customer data link (Modbus RTU) kVA (per phase, average & percent)

• Cooling System

  Caterpillar extended life coolant Coolant drain line with valve Coolant level sensors JWAC Radiator fan and fan drive Fan and belt guards

• Exhaust System

  Dry exhaust manifold Flanged faced outlet(s)

• Fuel System

  Secondary fuel filters Flexible fuel lines - shipped loose Fuel cooler; not included with packages without radiator Fuel priming pump

• Generators And Attachments

  Form wound 3 Phase brushless, Salient pole Class H insulation, Class F temperature rise at 40C ambient (105C prime/130C standby) Winding temperature detectors Permanent magnet excitation (PMG) Anti-condensation space heater Right side extension terminal box, busbar connections, top mounted, bottom cable entry 6 Lead NEMA standard hole pattern

• Governing System

  ADEM III

• Literature

  Parts book Operation & Maintenance Manual

• Lube System

  Integral lube Oil cooler Fumes disposal Oil drain lines and valve Oil filter, filler and dipstick Lubricating oil Gear type lube oil pump

• Mounting System

  Rubber anti-vibration mounts - shipped loose Rails - engine/generator/radiator mounting

• Starting / Charging System

  Battery disconnect switch 45 Amp Charging alternator Battery and battery rack w/cables 24 Volt electric starting motor

• General

  Flywheel and flywheel housing-SAE No. 00 SAE standard rotation Paint - Caterpillar yellow with high gloss black rails & radiator Right hand servicing

Optional Equipment

• Air Inlet System

  Air inlet protection Remote air inlet adapters Dual element air cleaners Heavy duty air cleaners

• Circuit Breakers

  Busbar connections P Frame breaker connections R Frame breaker connections Optional busbar power connections Circuit breaker harnesses Masterpact breaker connections Cable entry options 2000, 2500, 3200, 4000 Amp, 4 Pole, IEC rated Circuit breakers 2000, 2500, 3200, 4000, 5000 Amp, 3 Pole, IEC rated Circuit breakers 1600, 2000, 2500, 3000, 4000, 5000 Amp, 3 Pole, UL-100% rated Circuit breakers

• Power Termination

  Circuit breakers, IEC compliant

• Control Panel

  Customer interface options Mounting group - External box clips EMCP 4.4 PC monitoring (Remote and local) Ground Load share module options Annunciator modules Auxiliary box Language options Remote speed adjust Vandal proof panel door Voltage raise/lower switch Generator temperature monitoring

• Cooling System

  Expansion tanks Optional Serpentine radiators Water level switch gauges Optional ATAAC radiators

• Exhaust System

  Flexible fittings Elbows Flanges and exhaust fittings Flanges Y Adapters Mufflers

• Fuel System

  Duplex fuel filters Primary fuel filters

• Generators And Attachments

  Differential current transformers - 8.7 and 15 kV class Alternator air cleaners

• Instrumentation

  Pyrometer and thermocouples

• Lube System

  Manual prelube pump Lube oil in standard sump Oil level regulator Electric prelube pumps

• Mounting System

  Spring type vibration isolators IBC Seismic vibration isolators NORAD Puck style low efficiency lsolators

• Power Connections

  Neutral ground connections 2700 & 3000 Frame Grounding groups

• Special Tests / Reports

  IBC Certifications Generator set test report Torsional vibration analysis PGS Test report @ 1.0 power factor PGS Test report @ 0.8 power factor Standard engine test charge Fuel consumption test Generator set consumption test

• Starting / Charging System

  Starter cover Electric starting motors Air pressure regulator 24 Volt battery set - Dry Jacket water heaters Engine barring group 10, 20, 35 and 50 Amp Battery chargers Air starting motors

• General

  Special paint colors US aid emblem