3412C Generator Set

Standard Equipment

• Air Inlet System

  Air cleaner, single element canister type with service indicator

• Control Panel

  EMCP 4.2B Customer data link (Modbus RTU) 2 Programmable relay outputs (Form C) Features include: Voltage adjust Failure to start (overcrank) Volts (L-L & L-N) Reverse power (kW) (32) Accessory module data link Over/under voltage (27 / 59) Speed adjust Low coolant temperature Oil pressure (psi, kPa or bar) Environmental sealed front face Generator temperature monitoring module DC volts Serial annunciator module data link Reverse reactive power (kVAr) (32RV) Amps (per phase & average) High coolant temperature 24 Volt DC operation Communications Power factor (per phase & average) Compatible with the following optional modules: Low coolant level Text alarm/event descriptions Digital I/O module 6 programmable digital inputs Low oil pressure Remote Serial annunciator Engine cycle crank Local annunciator Digital indication for: Over/under frequency (81 o/u) Generator phase sequence Emergency stop kVAr (per phase, average & percent) Run/auto/ stop/control Operating hours kVA (per phase, average & percent) Warning/shutdown with common LED indication of shutdowns for: Emergency stop pushbutton Frequency (Hz) coolant temperature Overspeed 4 programmable relay outputs (Form A) kW-hr (total) 2 Programmable digital outputs Remote CAN annunciator Overcurrent (50 / 51) kW (per phase, average & percent) RPM Programmable protective relaying functions:

• Cooling System

  Radiator with guard (Sized for 50 degrees C) Coolant level shutdown Coolant drain line with valve, piped to edge of base Fan and belt guards Caterpillar extended life coolant

• Exhaust System

  Stainless steel exhaust flex with ANSI style outlet flange, gasket, bolts and mating weld flange, shipped loose

• Fuel System

  Primary and Secondary fuel filters Fuel priming pump Flexible fuel lines terminated on base Water seperator

• Generator And Attachments

  2:1 Volts/Hz Busbar termination 3-phase sensing Class H insulation Reactive droop VR6 voltage regulator SR4B self excited 12 Leads Class F temperature rise

• Governing System

  Cat electronic governor

• Lube System

  Oil drain line with valve, piped to edge of base Lubricating oil Oil filter Fumes disposal, piped to front of radiator

• Mounting System

  Base, formed steel with linear vibration isolators between base and engine-generator

• Starting / Charging System

  45 amp Charging alternator Battery with rack, cables Fuel shutoff solenoid 24 volt starting motor

Optional Equipment

• Air Inlet System

  Heavy duty air cleaners Dual element air cleaners Open element air cleaners

• Circuit Breakers

  1600 Amp, 3 pole, Non-UL, 100% rated, 24 volt DC shunt trip 1250, 1600 Amp, 3 pole, IEC 100% rated, 24 volt DC shunt trip

• Control Panel

  Generator temperature monitoring package EMCP 4.4 First local annunicators Vandal proof panel door Remote custom annunicator EMCP 4.3 Local discrete I/O package Common alarm/shutdown relay Ground fault relay Generator running VFC

• Cooling System

  Radiator duct flange Jacket water heaters

• European Certifications

  Eurasian Conformity (EAC) mark

• Exhaust System

  Through wall installation kit Mufflers Manifold and turbocharger guards Elbow kit

• Generator And Attachments

  Permanent magnet excitation (PMG) Space heater Digital voltage regulator Oversize and premium generators

• Lube System

  Manual sump pump

• Mounting System

  Fuel tank base (1200 ltr)

• Special Tests / Reports

  PGS Test report @ 0.8 power factor PGS Test report @ 1.0 power factor

• Starting / Charging

  Oversize batteries Battery chargers Battery disconnect switch Heavy duty starting system

• Governing System

  Electronic load share