3516C Generator Set

Standard Equipment

• Air Inlet System

  Air cleaner; single element canister type

• Cooling

  Package mounted radiator

• Exhaust

  Exhaust flange outlet

• Fuel	Primary fuel filter with integral water separator Fuel priming pump

• Generator

  IP23 Protection Matched to the performance and output characteristics of Cat engines

• Power Termination

  Busbar

• Control Panel

  EMCP 4 Genset Controller

• Control System

  24 Volt DC operation EMCP 4.2B Environmental sealed front face RFI suppression Caterpillar' s Voltage Regulato Emergency stop pushbutton 3 Phase voltage sensing Generator set packages include: Text alarm / event descriptions Generator mounted - rear facing KVAR / PF modes IVR includes reactive droop capability Min / max exciter Limiter and exciter diode monitor Speed adjust Controls: Engine cycle crank Auto / start / stop control Alarm acknowledge Engine cool PLC functionality Load histogram feature Lamp test Customizable screens Digital indication for: 3 Phase RPM 0 True RMS AC metering +/- 2% accuracy DC volts Operating hours Coolant temperature Amps (per phase & average) Volts (L-L & L-N) Oil pressure (psi, kPa or bar) Power Factor (per phase & average Frequency (Hz) kVAr (per phase, average & percent) kVA (per phase, average & percent kW (per phase, average & percent) Warning/shutdown with common LED indication of shutdowns for: Low oil pressure - High coolant temperature - Overspeed - Emergency stop - Failure to start (overcrank) - Low coolant temperature - Low coolant level - kVAr-hr (total) Low oil pressure kW-hr (total) Cat Connect Failure to start (overcrank) Overcurrent (50/51) Communications: Low coolant temperature Reverse reactive power (kVAr) (32RV) Low coolant level 6 Customer programmable digital inputs 1 Programmable relay outputs (Form C) High coolant temperature 4 Programmable relay outputs (Form A) Programmable protective relaying functions: Number of I/O varies on options selected: 1 Programmable digital outputs Serial annunciator module data link Accessory module data link Over / under frequency (81 o/u) Over / under voltage (27/59) Overspeed 3 Analog inputs Generator phase sequence Reverse power (kW) (32)

• Governing System

  ADEM A3

• Cooling System

  ATAAC - 3516E Package radiators shipped installed Certified standard PGS provided

• Exhaust System

  Dry exhaust manifold Flanged faced outlet(s)

• Fuel System

  Flexible fuel lines - shipped loose Fuel cooler; not included with packages without radiator Secondary fuel filters

• General

  Right hand servicing Paint - Caterpillar Yellow except rails and radiators gloss black Flywheel and flywheel housing - SAE No. 00 Caterpillar yellow with high gloss black rails and radiator SAE Standard rotation

• Generator And Attachments

  Permanent magnet Low Voltage: Random wound - Internal Excitation - Winding temperature detectors - NEMA Class H insulation, Class H temperature rise at 40C ambient (125C prime/150C standby) - Busbar connections, top center mounted, top cable entry - NEMA standard hole pattern Winding temperature detectors Permanent magnet Busbar connections, right side extension box, bottom cable entry 6 Lead Form wound NEMA standard hole pattern Medium Voltage: Class H insulation, Class F temperature rise at 40C ambient (105C prime / 130C standby) NEMA Class H insulation, Class H temperature rise at 40C ambient (125C prime/150C standby) High voltage: Anti condensation space heater 3 Phase brushless, salient pole

• Literature

  English

• Lubrication System

  Integral lube oil cool Gear type lube oil pump Fumes disposal Oil drain lines and valve Oil filter, filler and dipstick Lubricating oil

• Mounting System

  Anti-vibration mounts (shipped loose) Rubber anti-vibration mounts (shipped loose) Rails - engine / generator / radiator mounting

• Starting System

  Battery disconnect switch 45 Amp charging alternator 24 Volt electric starting motor Battery and battery rack w/cables

Optional Equipment

• Control System

  EMCP 4.3, EMCP 4.4

• Air Inlet System

  Dual element air cleaner Single element filter

• Exhaust

  Exhaust mufflers

-->

Generator

Anti-condensation heater Oversize and premium generators Excitation: [ ] Permanent Magnet Excited (PM) [ ] Internally Excited (IE)

Cooling System

Standard ambient radiators Coolant Optional installed ATAAC radiators Optional installed radiators Water level switch gauges Standard ambient ATAAC radiators

Power Termination

Circuit breakers, UL listed Circuit breakers, IEC compliant

Crankcase System

No explosion relief valves Explosion relief valves Ventilation system

Control Panels

Load share module Digital I/O module Generator temperature monitoring & protection Remote monitoring software

Mounting

IBC isolators

Exhaust System

Y-Adapters Mufflers Exhaust offset Flexible fittings Tier 4 clean emission MOD Kits Flange and exhaust expanders Elbows Tier 4 clean emissions module Clean emission parts Tier 4 dosing cabinet Flanges

Starting/charging

Oversize batteries Air starting motor with control and silencer Battery chargers Heavy-duty starting system Charging alternator Jacket water heater

Fuel System

Fuel Priming Pumps (Tier 4) - Manual or electric Primary Fuel Filter

General

The following options are based on regional and product configuration: UL 2200 package Enclosures: sound attenuated, weather protective EEC Declaration of Conformity US aid emblem CSA Certification Integral & sub-base fuel tanks EU Certificate of Conformance (CE) Integral & sub-base UL listed dual wall fuel tanks Seismic Certification per applicable building codes: IBC 2000, IBC 2003, IBC 2006, IBC 2009, CBC 2007 Special paint (Colors other than Caterpillar yellow or high performance paints) Automatic transfer switches (ATS)

Generators And Attachments

Generator conversion Space heater Thermostate for space heater Differential current transformers (DCT) 8.7 kV and 15 kV classes Low / Medium voltage: 380/400/415 volts, 3 phase 1500 rpm. RW, IE, No. of Leads = 6, Pitch = .6667: 1600 Frame Alternator air cleaner Low / Medium voltage: 380/400/415 volts, 3 phase 1500 rpm. RW, PM, No. of Leads = 6, Pitch = .6667: 1600 and 1800 Frames

Instrumentation

Pyrometer and thermocouples

Lubrication System

Lube oil in standard sump Oil level regulator Prelube pumps

Mounting System

Puck style low efficiency isolators IBC vibration isolators Spring type vibration isolators

Power Connections

Neutral ground connections Left side power connections Low voltage circuit breakers Ground cables between generator and terminal box 2700 Frame, four lead, four terminal Rear power connections Center post busbar Right side power connections

Special Tests / Reports

Fuel consumption test Generator set fuel consumption test generator test report Canadian Standards Association certification Torsional vibration analysis reports PGS test report @ 1.0 power factor IBC certification Standard engine test charge PGS test report @ 0.8 power factor OSHPD certification

Starting And Charging

Air pressure regulator Air starting motors Jacket water heaters 10, 20, 35 and 50 amp battery chargers Starter cover Engine barring device Electric starting motors 24 Volt battery set - Dry

Extended Service Coverage

Platinum, Gold and Silver coverage